Register July 2023 No. 811
Chapter Trans 212
STANDARDS FOR THE INSPECTION OF BRIDGES IN WISCONSIN
Trans 212.02 Definitions.
Trans 212.03 Application of chapter.
Trans 212.04 Responsibility for inspection.
Trans 212.05 Qualification of personnel.
Trans 212.06 Frequency of inspections.
Trans 212.07 Frequency of inventory.
Trans 212.12 County status under department direction.
Trans 212.13 Compliance and county costs.
Trans 212.01
Trans 212.01 Purpose. The purpose of this chapter is to interpret and implement s.
84.17 (3), Stats., and to provide standards for the continuing inspection of bridges in this state.
Trans 212.01 History
History: Cr.
Register, February, 1982, No. 314, eff. 3-1-82.
Trans 212.02(1)(1)
“AASHTO manual" means the
Manual for Condition Evaluation of Bridges, 1994 as revised by Interim Specifications, Bridges 1995-1998, published by the American association of state highway and transportation officials, 444 North Capitol Street, N.W., Washington, D.C. 20001.
Trans 212.02 Note
Note: This manual is on file at the offices of the Division of Transportation Infrastructure Development, Wisconsin Department of Transportation, the Secretary of State, and the Legislative Reference Bureau.
Trans 212.02(2)
(2) “Bridge" means a structure, including supports, erected over a depression or an obstruction, such as water, a highway, or a railway, having a track or passageway for carrying traffic or other moving loads, and having an opening measured along the center of the roadway of more than 20 feet between the undercoping of abutments or spring lines of arches, or extreme ends of the openings for multiple boxes. It may include multiple pipes where the clear distance between openings is less than half of the smaller contiguous opening.
Trans 212.02(3)
(3) “Bridge inspector's training manual" means the
Bridge Inspector's Training Manual 90, 1991, published by the federal highway administration and available from the superintendent of documents, U.S. government printing office, Washington, D.C. 20402.
Trans 212.02 Note
Note: This manual is on file at the offices of the Division of Transportation Infrastructure Development, Wisconsin Department of Transportation, the Secretary of State, and the Legislative Reference Bureau.
Trans 212.02(4)
(4) “Department" means the Wisconsin department of transportation.
Trans 212.02(5)
(5) “Inspection" means the examination of a bridge, the evaluation of the physical condition observed, and the report of the observations and evaluations on a bridge inspection report form adopted by the department.
Trans 212.02 Note
Note: The bridge inspection report forms referred to in this subsection are: (1) “Field Bridge Inspection Report," #E-M-30, and (2) “Supplemental Information to Field Bridge Inspection,"#E-M-36. Copies of these report forms may be obtained from the department.
Trans 212.02(6)
(6) “Inventory" means the gathering and reporting of all information required on the bridge inventory form adopted by the department.
Trans 212.02(7)
(7) “Posting" means the placement of regulatory signs at a bridge indicating the safe load-carrying capacity of the bridge.
Trans 212.02(8)
(8) “Rating" means determining the safe load-carrying capacity of a bridge.
Trans 212.02 History
History: Cr.
Register, February, 1982, No. 314, eff. 3-1-82; am. (1) and (8),
Register, July, 1992, No. 439, eff. 8-1-92; correction in (3) to (6) and (8) made under s. 13.93 (2m) (b) 1., Stats.,
Register, July, 1992, No. 439; am. (1) and (3),
Register, July 1999, No. 523, eff. 8-1-99.
Trans 212.03
Trans 212.03 Application of chapter. The bridge inspection and inventory standards in this chapter apply to all highway bridges which either lie within or cross the borders of the state of Wisconsin. Bridges carrying only railroad traffic and bridges used only by pedestrians, bicycles, and recreational vehicles are excluded from the application of this chapter.
Trans 212.03 History
History: Cr.
Register, February, 1982, No. 314, eff. 3-1-82.
Trans 212.04
Trans 212.04 Responsibility for inspection. The responsibility for the continuing inspection program shall be as follows:
Trans 212.04(1)
(1) The department shall inspect highway bridges on the state trunk highway system and all other bridges for which the department has been assigned maintenance responsibility.
Trans 212.04(2)
(2) Each local authority or other authority having jurisdiction over a non-department maintained bridge shall inspect the highway bridges on highways under its jurisdiction.
Trans 212.04(3)
(3) When the department determines that a local authority or other authority having jurisdiction over a non-departmental maintained bridge has failed to inspect any highway bridge as required, the department shall inform the county highway commissioner of the county in which the bridge is located of the inspection failure and shall direct the county to inspect or cause the bridge to be inspected. Upon receipt of the department's notice and direction, the county shall perform the bridge inspection or cause it to be performed.
Trans 212.04 History
History: Cr.
Register, February, 1982, No. 314, eff. 3-1-82; emerg. cr. (3), eff. 8-20-85; cr. (3),
Register, April, 1986, No. 364, eff. 5-1-86.
Trans 212.05
Trans 212.05 Qualification of personnel. Individuals involved in the inspection of bridges as required by this chapter shall meet the minimum requirements set forth in the AASHTO manual.
Trans 212.05 History
History: Cr.
Register, February, 1982, No. 314, eff. 3-1-82.
Trans 212.06(1)(1)
State-owned or state-maintained bridges shall be inspected at regular intervals not to exceed 2 years.
Trans 212.06(2)
(2) Locally owned bridges shall be inspected at regular intervals not to exceed 2 years.
Trans 212.06(3)
(3) The maximum inspection interval specified in subs.
(1) and
(2) may be increased from 2 years to no more than 4 years for certain types or groups of bridges where past inspection reports, favorable experience and analysis by the department justifies an increased inspection interval. Written concurrence of the federal highway administrator shall be obtained by the department before the inspection interval is increased.
Trans 212.06(4)
(4) Interim inspections at intervals other than those specified in subs.
(1) and
(2) shall be conducted as found necessary by the maintaining authority on bridges that are posted, bridges subjected to excessive run-off that may cause scour, and bridges that have known deficiencies. The maintaining authority shall keep a record of interim inspections available for review by the department and federal authorities. If the maintaining authority has failed to perform the inspection, the county highway commissioner in the county in which the bridge is located shall perform the interim inspections as directed by the department and keep a record of the interim inspections available for review by the department and federal authorities. Upon receipt of the department's notice and direction, the county shall perform the interim inspections or cause them to be performed.
Trans 212.06 History
History: Cr.
Register, February, 1982, No. 314, eff. 3-1-82; emerg. am. (3), eff. 8-20-85; am. (3),
Register, April, 1986, No. 364, eff. 5-1-86; am. (1), renum. (3) to be (4), cr. (3),
Register, July, 1999, No. 523, eff. 8-1-99.
Trans 212.07
Trans 212.07 Frequency of inventory. An inventory shall be maintained for each bridge. Changes in inventory data or postings shall be reported to the appropriate department official or officials when the bridges are inspected and significant changes occur. The inventory of a new bridge shall be obtained upon completion of its construction and the information shall be submitted to the department at that time for use in maintaining the statewide bridge file.
Trans 212.07 History
History: Cr.
Register, February, 1982, No. 314, eff. 3-1-82
; am.
Register, July, 1999, No. 523, eff. 8-1-99.
Trans 212.08
Trans 212.08 Inspection. The items to be inspected on each bridge include, but are not limited to, the items specified on the bridge inspection report form. The bridge inspector's training manual shall be used as a guide to additional items to be inspected and to the detail required in special cases.
Trans 212.08 History
History: Cr.
Register, February, 1982, No. 314, eff. 3-1-82
; am.
Register, July, 1999, No. 523, eff. 8-1-99.
Trans 212.09
Trans 212.09 Ratings. Each bridge required to be inspected under this chapter shall be rated to determine its safe load-carrying capacity. Significant changes in the condition of a bridge shall be reported to the department as soon as possible. When the significant change affects the rating of the bridge, the bridge shall be rerated by the maintenance authority within 7 calendar days of the inspection. When the inspection or rerating results in a recommendation for posting, change in posting, or closure of the bridge, the department shall be notified within 7 calendar days of the inspection or rerating. Ratings shall be determined in accordance with the AASHTO manual.
Trans 212.09 History
History: Cr.
Register, February, 1982, No. 314, eff. 3-1-82; am.
Register, July, 1992, No. 439, eff. 8-1-92.
Trans 212.10
Trans 212.10 Posting. When it is determined by the department that the maximum load under state law exceeds the load permitted on a bridge as described in the AASHTO manual, the bridge shall be posted for weight limits or closed. The department shall post or close bridges on the state trunk highway system and all other bridges for which the department is the maintaining authority. Each local authority shall post or close the bridges on highways under its jurisdiction. When a local authority fails to post or close a bridge as required, the department shall inform the county highway commissioner of the county in which the bridge is located and direct the county to post or close the bridge or cause the bridge to be posted or closed. Upon receipt of the department's notice and direction, the county shall post or close the bridge or cause it to be posted or closed. After the erection of signs or barriers associated with the posting or closing of the bridge by the county, the local maintaining authority of the bridge is responsible for the maintenance of the signs or barriers.
Trans 212.10 History
History: Cr.
Register, February, 1982, No. 314, eff. 3-1-82; emerg. am. eff. 8-20-85; am.
Register, April, 1986, No. 364, eff. 5-1-86
; am.
Register, July, 1999, No. 523, eff. 8-1-99.
Trans 212.11
Trans 212.11 Reporting. The reporting of bridge inspections shall be as follows:
Trans 212.11(1)
(1) Bridges for which the department has inspection responsibility shall be reported for maintenance purposes for the year in which they were inspected. The department personnel responsible for these bridge inspections shall submit the inspection reports for updating the statewide bridge file to the appropriate department official or officials by January 15 of the appropriate year.
Trans 212.11(2)
(2) Each authority having jurisdiction over a bridge for which the department has no inspection responsibility shall report the results of all its bridge inspections to the county highway commissioner of the county in which the authority is located by January 1 of each odd year.
